Hi all,
Decided to clean the Haldex gauze filter and change the rear diff and front transfer box oil while I was at it. There doesn't seem to be many guides on the rear diff and transfer box so attached what I did below.
Just to clarify the difference between the Haldex drain/fill and rear diff drain fill.
Haldex
Rear Diff
Recommend a fluid transfer pump to fill like this one
Steps.
1) Undo fill plug (5mm hex)
2) Undo drain plug (5mm hex)
3) Allow to fully drain
4) Re-install drain plug
5) Fill with new rear diff oil (I used GL-5 75w-90 but do your own research) until it starts coming out of the fill point (approx 1.1 litres)
6) Re-install fill plug and check for leaks
Car has 64k kms and the old oil looked very clean with a light honey colour
Front transfer box:
Follow steps as above with these drain and fill points
The fill point is quite hard to see and access but is close to the right hand side driveshaft
Colour was a little bit darker than the rear but still looked clean
Hope this helps, ask away if you have any questions.
Decided to clean the Haldex gauze filter and change the rear diff and front transfer box oil while I was at it. There doesn't seem to be many guides on the rear diff and transfer box so attached what I did below.
Just to clarify the difference between the Haldex drain/fill and rear diff drain fill.
Haldex
Rear Diff
Recommend a fluid transfer pump to fill like this one
Steps.
1) Undo fill plug (5mm hex)
2) Undo drain plug (5mm hex)
3) Allow to fully drain
4) Re-install drain plug
5) Fill with new rear diff oil (I used GL-5 75w-90 but do your own research) until it starts coming out of the fill point (approx 1.1 litres)
6) Re-install fill plug and check for leaks
Car has 64k kms and the old oil looked very clean with a light honey colour
Front transfer box:
Follow steps as above with these drain and fill points
The fill point is quite hard to see and access but is close to the right hand side driveshaft
Colour was a little bit darker than the rear but still looked clean
Hope this helps, ask away if you have any questions.