There's a thread on here somewhere with good pics of how to remove the egr , it is fairly simple.
once it's off you remove the inlet manifold,...
Vacuum unit on inlet manifold. They have a diaphragm inside which can split.
Cheap fix, about £20. Diy job if you're ok with it.
I did mine a few...
2007, could be, been using for really short trips.
I'm hoping intake manifold is ok, i had it off and cleaned out when replacing vacuum unit a...
Just done it again, appears sluggish beforehand. Any ideas ? Thanks
Hi, happened a couple of times lately. 2.0 tdi 170.
Glow plug light flashing, limp mode. Stop car, restart and all ok.
No error codes showing....
I read on here somewhere that if you hold the esp button the rev s will go above 3000, not tried it.
mine smokes on idle, not straight away,...
Dgorie, it's easy. Once the manifold is off you can see how the vacuum unit comes off.
manifold easily unbolts, watch out for one bolt which is...
You're welcome, shout out if you get stuck.
You need to remove the inlet manifold to access the part, once off its obvious how it is replaced.
Inlet manifold comes off easily, remove egr...
About £15 from tps
Easy fix, did mine a few weeks back
Just re-read your post, i didn't have smoke under bonnet.
The plastic cogs rounded off on my egr, this caused the dpf to block. Once the new egr was on and the codes cleared loads of smoke came out while...
Dpf cleaning itself ? Are you able to take it for a run at around 2k rpm for about 20 minutes ?
Could also be egr issue, might be worth taking it...
Hi, need help please.
Last week i had a problem with egr, p404 code. After a couple of days the dpf light came on.
I replaced the egr as the cogs...
No, just the egr.
Getting code p403 now too :)
What is the most likely cause of this code ?
I took egr off about 3 months ago and gave a thorough clean along with inlet manifold, only...
Great, thank you
Hi, if my car doesn't show the dpf warning light when i turn on the ignition can i assume it doesn't have a dpf ?
Brd code, 2007
You can take it off in about 15 - 20 minutes then have a look at it. Maybe worn plastic cogs.
Separate names with a comma.