1. This site uses cookies. By continuing to use this site, you are agreeing to our use of cookies. Learn More.

Saloon Window Removal

tonya4 Jul 8, 2012

  1. tonya4

    tonya4 TDi Powerrrr

    408
    5
    18
    hi,how easy is it to remove the small side window,behind the rear doors,on a ssloon?
    thanks in advance
    tony
     
  2. NineNails

    NineNails Proud sponsor of the snack food industry

    593
    6
    18
    Horrible, horrible job and nearly impossible without breaking something. Even a pro auto glass fitter will struggle with these!
     
  3. tonya4

    tonya4 TDi Powerrrr

    408
    5
    18
    um ok,was hoping they might bolt in like vectra b's do

    thanks
    tony
     
  4. NineNails

    NineNails Proud sponsor of the snack food industry

    593
    6
    18
    There's little clips on the trim that you cant get off without breaking. I tried getting one out of a breaker for someone and gave up after mangling/breaking stuff. I spoke to an Autoglass mate about it and he said they are a nightmare
     
  5. tonya4

    tonya4 TDi Powerrrr

    408
    5
    18
    neer mind,will leave them in then!
    cheers
    tony
     
  6. murran

    murran Well-Known Member

    1,545
    39
    48
    you on about the quarter window in the door or the one in the car?

    if its in the door its not that bad......
    bob the door card off (remove screws and slot it upwards!), unbolt the frame off the door (4x45 torx bolts) (marking where the bolts and adjustment wedges were before unbolting them) unclip the wiring loom off the frame, send the motor/window reg fully down, unplug the window motor.
    remove the frame from the door and put it somewhere you can work on it (lounge floor?) then remove the main window. remove the bar inbetween the quarter glass and where the main window was, the quarter glass will now come out.

    when putting it together the marks you made (red touch up pen/brush is best) to the bolts and wedges are invaluable to get the adjustment and fit back where it was!

    ive never changed the one thats in the car so can't comment on that....
     
  7. tonya4

    tonya4 TDi Powerrrr

    408
    5
    18
    I mean the one on the car,behind the rear door

    tony
     
  8. murran

    murran Well-Known Member

    1,545
    39
    48
    never had one out. sorry.
     
  9. NineNails

    NineNails Proud sponsor of the snack food industry

    593
    6
    18
    I know of a lad with a B3 90 (the rear quarter glass fits the same) and he's just had one smashed. It's possibly going to write off the car...
     

Share This Page