1. This site uses cookies. By continuing to use this site, you are agreeing to our use of cookies. Learn More.

Cracked my Sump

docurley Jun 30, 2008

  1. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    Well on my way to Lydden Race track I hit a speed hump which mad an almighty thump but did not realise it had cracked the sump.


    Well after doing a 120 mile round trip I start the car only to be met with oil light which I thought was strange so I turn her off check the oil and there’s none. I have a look underneath and the last few dregs are spilling on the floor "oh siht" I now have to do my oil pump sooner than I thought.:banghead:

    So does anyone know a cheap place to pick-up an Oil pump and sump by any chance?
     
  2. PaulJC84

    PaulJC84 Owner

    2,878
    13
    38
    Nightmare, least you made it home ok.
     
  3. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    Well I knocked the sump on the way out so I was real lucky there was any oil still in her.

    Been phoning around for parts and the Oil pump is a killer at £177.59 the sumps only £64.75 from Audi so things not looking good bar the sump.:(
     
  4. brendan

    brendan 98 A4 1.8SE

    137
    0
    16
    you can get new oil pumps on ebay for about £60, or did you specifically want OEM?
     
  5. PaulJC84

    PaulJC84 Owner

    2,878
    13
    38
    How come you need an oil pump? I remember reading before that you were planning on replacing it. They have a service period?
     
  6. aragorn

    aragorn "Stick a V8 in it!" Staff Member Moderator VCDS Map User

    17,775
    674
    113
    maybe its a part thats prone to failure?

    although the pickup is probably a bigger failure point than the pump itself.

    I guess once you've got it all off its probably silly not to swap the pump out while your there.

    Depending on how scored the original housing is you can sometimes get a rebuild kit for the pump which might be a cheaper option than a whole new unit?
     
  7. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    Well I do have pickup issues hence why I was going to replace the pump but if a rebuild kit will do the job with a new pickup pipe and would go that way but I don't care if I buy OEM or After market.

    I would also be intrested in a repair kit for the sump if there is one so any leads would be good.
     
  8. AUDI TURBO

    AUDI TURBO Member

    577
    0
    16
    GOD OIL PUMP EXPENSIVE
     
  9. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    You can say that again although Euro Car Parts do one for £85 and yes I checked ebay but they don't have one for my engine.
     
  10. brendan

    brendan 98 A4 1.8SE

    137
    0
    16
    what engine code do you have?
     
  11. Randomjim

    Randomjim Active Member

    2,752
    3
    36
    Ouch. Trouble with running a low car i guess.

    Slightly off topic but does anyone make a metal sump guard for the B5 A4? I've seen them for the passat maybe that would fit?
     
  12. jcb

    jcb Active Member VCDS Map User

    4,132
    12
    38
    Get an OEM one, you will only regret it otherwise
    $170 from Bob at QED
     
  13. hiltoa

    hiltoa VAG erfahren

    298
    1
    16
    You could rivet a layer of ali sheet to the under tray, that might offer some protection and not weigh too much...
     
  14. Andy.B

    Andy.B Member

    401
    0
    16
    Doc just done my oil pump, and sump gasket... i have my old oil pump still if you want it? I put a new one in thinking it was the pump but it was the old bunged up pickup pipe.. checked all tollerences against the new one i put in and there is no wear or difference at all, i could clean it up if you like and you could have it if you want?
     
  15. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    Well I bodged up the old sump with some sort of cemical metal stuff but it wont hold for ever but will get me by.

    Andy what engine did it come off or if it's got a part number then I can look it up to see if it's the same.

    Oh and what you want for it by the way.:yes:
     
  16. Andy.B

    Andy.B Member

    401
    0
    16
    Its off my AEB 1996 engine... don't want anything for it as far as i was concerned it was going to sit on my shelve in the shed as a spare lol. Dunno the part numbers as its over my parents house in my shed at the mo. Just pay postage :yes:
     
  17. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    That would be sweet but I think it may be the wrong fitment as I'm a AJL 2000 engine but I will look it up plus I may just go the pickup route instead.
     
  18. Z82

    Z82 Member

    454
    0
    16
    Thats a bit of a pisser Doc but at the same time you were damn lucky
     
  19. docurley

    docurley Moderator Staff Member Moderator

    4,060
    82
    48
    Very
     
  20. Broken Byzan

    Broken Byzan Photographic Moderator Staff Member Moderator VCDS Map User quattro Audi A4

    13,224
    464
    83
    I am pretty sure it will physicaly fit, but you will lose the oil temp sender, as they are in the sump on the later models as i have an APU sump on mine with sender, i just didnt connect it
     

Share This Page