1. This site uses cookies. By continuing to use this site, you are agreeing to our use of cookies. Learn More.

Car just tried to kill itself! (Diesel Engine ran away)

Discussion in 'A3/S3/Sportback (8P Chassis)' started by giblets46, Jan 22, 2008.

  1. giblets46
    Offline

    giblets46 Member

    Joined:
    Nov 20, 2006
    Messages:
    156
    Likes Received:
    0
    Hi all, after 9months and 31,000miles looks like my car had enough of me and tried to commit suicide!
    Started calmly enough, earlier in the day, accelerating, the car hesitated around 2,400rpm, with about 10-20secs of heavy white smoke, was fine after that, no warning lights or anything, but called Audi and booked it in to be looked at.
    Had an appointment, left and drove off, about an hour later, at traffic lights, the engine just went haywire, all the way to 6,000rpm (the max for about 4 secs, was like a TV special effect with all the white smoke), it then went back to idle for 5 secs then up to 6,000rpm again, with lots of white smoke! Again no engine warning lights or anything.
    Obviously pulled to the side of the road. RAC guy came along and switched on the engine, and was fine for 20secs, when fault re-occured, he jumped so far! Had no idea what the problem was but thought it could be the throttle sensor
    Anyway, car is now with Audi, though on the plus side,getting an A6 tiptronic in replacement as courtesy car!
    #1
  2. Nelson15
    Offline

    Nelson15 Member

    Joined:
    May 25, 2007
    Messages:
    71
    Likes Received:
    0
    At least it happened for the RAC guy, every time I've called one out the fault's corrected itself and I look like and feel like a muppet.

    Best of luck with it!
    #2
  3. coupe-se
    Offline

    coupe-se Member

    Joined:
    Oct 31, 2006
    Messages:
    246
    Likes Received:
    1
    I'm sure someone more technical will clarify/put me right, but I believe that diesel engines that 'run away' often are burning the engine oil as a source of fuel.
    I believe that the unrestricted supply of oil (rather than a fuel pump restricting the max flow rate of diesel) can cause the engine to rev higher and higher until goes bang.

    I'm probably completely wrong but maybe the turbo has gone allowing oil to be blown into the engine and causing the white smoke you described??

    At least its under warranty and it'll be fixed at Audi's cost!!:icon_thumright:
    #3
  4. Savage
    Offline

    Savage Savage

    Joined:
    Aug 15, 2007
    Messages:
    68
    Likes Received:
    0
    Oil tends to burn with blue smoke rather than white. It's definitely going to be something electronic causing it jump like that. Pretty damn dangerous that, I would pound your dealer for a bunch of freebies after that. Imagine the "what ifs"
    #4
  5. Gti Jazz Blue
    Offline

    Gti Jazz Blue Active Member

    Joined:
    Feb 26, 2007
    Messages:
    1,655
    Likes Received:
    6
    Yes you can get a run away diesel engine when it runs to destruction using its own oil.

    My mate who is a mechanic said that if one starts they all tend to find cover.

    He also has me worried about the first MOT as to do the emission test on a diesel thay have to bounce it off of the governor. Ouch.

    Paul
    #5
  6. TFSI
    Offline

    TFSI Born to Fish

    Joined:
    Jan 10, 2008
    Messages:
    532
    Likes Received:
    47
    Electronics deffo.

    If its away on its own oil the engine speed governor is inoperative and it just goes till it lets go. Seen a few truck diesels that have done this after a turbo failure and you would not believe the destruction it causes.
    #6
  7. giblets46
    Offline

    giblets46 Member

    Joined:
    Nov 20, 2006
    Messages:
    156
    Likes Received:
    0
    Just had a call fromt he guy at the garage, apparently something to do with a fuel pump 'in the rear' (a cam pump?), it was quite a bad line, reckoned it had become 'porous' and was letting in oil.
    Will update when i know more!
    They are keeping it in for an 'extended test drive' which propbably means if it wasn't broken before.....

    Edit: Just been given a call this morning; also getting a new turbo charger, the old one was 'whistling' apparently, presumably due to all the oil and gumph that was put through it during the previous problem.
    #7

Share This Page