Door problem

[Bradderz_1988]

The other day unlocked car and drivers door wouldn't open went through back door and opened with ease drove 12 miles or so to work and it worked fine when I tried it at work now this morning the passenger one did at the misses got a strop on as she thought I locked her out in the cold lol but again opened fine from the inside ??

Is it just the cold weather that's freezing the lock or is it a problem beginning to start ?

Any suggestions ??

 

[ScottD3]

Are locking pumps air or electric driven?


VCDS Scan?

 

[Bradderz_1988]

I would of thought air driven of the pump and electric side is just to let the comp no there's a fault or the doors are open for courtesy lights etc may be wrong though lol

 

[ScottD3]

I would of thought air driven of the pump and electric side is just to let the comp no there's a fault or the doors are open for courtesy lights etc may be wrong though lol

I think the change over was about the FL time.
PFL was air pump driven and FL was electric. I think.

If yours is a PFL, it will be air. so you could have a leak or something freezying stopping it from opening.
The VCDS will tell you if there is a fault with the pump, like if it ran on for to long which will indicate a air leak.

 

[slepy]

His is 99 1.8TQS so facelift

 

[ScottD3]

His is 99 1.8TQS so facelift

With electric door locks, not the air kind.

Can only think its cold and its effecting the motors.

 

[LeeT]

His is 99 1.8TQS so facelift

Mines a 99 and still prefacelift

With electric door locks, not the air kind.

Can only think its cold and its effecting the motors.

I think you'll find all b5's have air driven locks. Its only the tailgate/boot of the facelift thats electric

 

[ScottD3]

I think you'll find all b5's have air driven locks. Its only the tailgate/boot of the facelift thats electric

Thats where i'm getting confused then.
I thought FL went electric all round along with the boot.

 

[slepy]

Mines a 99 and still prefacelift

But not TQS

 

[griswold]

mine 99 facelift tqs air locks

 

[ScottD3]

So its air locks.

VCDS and check for a leak.

 

[aragorn]

You can tell if theres a leak by listening to the pump.

If its fine it whirrs for a couple of seconds at most. If its leaking it'll whirr for ages, 10-15secs.

If you dont fix it and it is a leak, you'll shatter the impeller in the pump.

 

[LeeT]

But not TQS

well technically it is. Its turbo, its quattro and sport suspension

 

[aragorn]

All B5's have vacuum locking anyway.

 

[ScottD3]

All B5's have vacuum locking anyway.

Thank you.
I will remember that.

 

[LeeT]

There's an echo in here

 

[slepy]

well technically it is. Its turbo, its quattro and sport suspension

So you have a quattro 1.8T pre-facelift?

EDIT: it's S4 isn't it?

 

[andyw82]

it will be the central locking pump mine has been faulty since i brought mine, it a 2000 faclift, when i first striped the pump cause nothing work the impella was shattered, so i got 1 from the scrapy, and swaped the impella over as they are coded to car so would need vagcom or someting to install! so after the swap i got my door to work but none of the rest! my door was perfect for a few month now if i unlock it only half unlocks it but if i pull the handle a few times it opens! best bet is your local scrappy, as the ones on ebay i think r a little expensive, i paid 10 from scrapyard! there seem to be 2 vacum lines on mine think 1 is for drivers door and the other for the other 3! hopes this helps abit!

 

[ScottD3]

You can by impeller kits off Ebay.
I'd buy one of them over a breaker unit.

 

[aragorn]

Buy a "4A0" pump from an Audi 80 or similar and swap the compressor from that. They're much sturdier.

 

[LeeT]

So you have a quattro 1.8T pre-facelift?

EDIT: it's S4 isn't it?

No **** Sherlock